Auto Repair Manual Free Download and Reviews » Dodge

2001 Dodge Ram 2500 BEARING NOISE Testing and Inspection

admin — Sat, 07 May 2011 14:44:43 +0000

download GEAR NOISE Axle gear noise can be caused by insufficient lubricant, incorrect backlash, incorrect pinion depth, tooth contact, worn/damaged gears, or the carrier housing not having the proper offset and squareness. Gear noise usually happens at a specific speed range. The noise can also occur during a specific type of driving condition. These conditions [...]

2001 Dodge Ram 2500 BEARING NOISE Testing and Inspection is a post from: Auto Repair Manual Free Download and Reviews

2000 Dodge RAM 1500 Van Fuel Pressure Leak Down Test

admin — Wed, 04 May 2011 09:53:34 +0000

download Use this test in conjunction with the Fuel Pump Pressure Test and Fuel Pump Capacity Test. Check Valve Operation: The electric fuel pump outlet contains a one-way check valve to prevent fuel flow back into the tank and to maintain fuel supply line pressure (engine warm) when pump is not operational. It is also [...]

2000 Dodge RAM 1500 Van Fuel Pressure Leak Down Test is a post from: Auto Repair Manual Free Download and Reviews

2006 Dodge RAM 1500 P2122-ACCELERATOR PEDAL POSITION SENSOR

admin — Wed, 04 May 2011 09:51:25 +0000

download brake pedal is pressed or has failed. Acceleration rate and Engine output are limited. One trip fault and the code will set within 5 seconds . ETC light is flashing. POSSIBLE CAUSES (F855) 5-volt supply circuit open (F855) 5-volt supply circuit shorted to ground (K23) APP sensor no.1 signal circuit open (K23) APP [...]

2006 Dodge RAM 1500 P2122-ACCELERATOR PEDAL POSITION SENSOR is a post from: Auto Repair Manual Free Download and Reviews

2007 Dodge Nitro R/T WHEEL ALIGNMENT

admin — Sat, 19 Mar 2011 11:49:50 +0000

download DESCRIPTION WHEEL ALIGNMENT NOTE: Suspension components with rubber/urethane bushings should be tightened with the vehicle at normal ride height. It is important to have the springs supporting the weight of the vehicle when the fasteners are torqued. If springs are not at their normal ride position, vehicle ride comfort could be affected [...]

2007 Dodge Nitro R/T WHEEL ALIGNMENT is a post from: Auto Repair Manual Free Download and Reviews

2007 Dodge Nitro R/T TRANSFER CASE REMOVAL DISASSEMBLY

admin — Sat, 19 Mar 2011 11:48:03 +0000

download 1. Raise vehicle. CAUTION: Do not allow propshafts to hang at attached end. Damage to joint can result. 2. 3. 4. 5. Remove the front and rear propeller shafts. Refer to REMOVAL . Support transmission with jack stand. Remove rear crossmember and skid plate, if equipped. Disconnect transfer case vent hose (4). [...]

2007 Dodge Nitro R/T TRANSFER CASE REMOVAL DISASSEMBLY is a post from: Auto Repair Manual Free Download and Reviews

2007 Dodge Nitro R/T DIAGNOSIS AND TESTING Harsh N-D Engagement

admin — Thu, 17 Mar 2011 13:56:19 +0000

download CORRECTION 1. Check for latest level TCM software. Perform the TCM 1. Transmission adaptation/calibration. adaptation procedure. Refer to STANDARD PROCEDURE . 2. Check TCM for DTCs. Repair 2. Transmission in limp-home mode. as needed. 3. Check engine mounts, transmission mount, driveshaft couplings, rear crossmember 3. Driveline lash/movement. mounts, axle mounts and axle lash. Harsh N-D [...]

2007 Dodge Nitro R/T DIAGNOSIS AND TESTING Harsh N-D Engagement is a post from: Auto Repair Manual Free Download and Reviews

2007 Dodge Nitro R/T FLUID LEVEL CONTROL DESCRIPTION

admin — Thu, 17 Mar 2011 00:27:15 +0000

download The oil level control is located on the electrohydraulic unit (4) and consists of the float (5) which is integrated into the electrohydraulic unit. The float is positioned to plug the opening (6) between the oil gallery (2) and gearset chamber (1) so that the rotating gearsets do not splash about in oil as the [...]

2007 Dodge Nitro R/T FLUID LEVEL CONTROL DESCRIPTION is a post from: Auto Repair Manual Free Download and Reviews

2007 Dodge Nitro R/T CONVERTER-TORQUE DESCRIPTION

admin — Thu, 17 Mar 2011 00:20:43 +0000

download CAUTION: The torque converter must be replaced if a transmission failure resulted in large amounts of metal or fiber contamination in the fluid. The torque converter is a hydraulic device that couples the engine crankshaft to the transmission. The torque converter consists of an outer shell with an internal turbine (1), a stator (3), [...]

2007 Dodge Nitro R/T CONVERTER-TORQUE DESCRIPTION is a post from: Auto Repair Manual Free Download and Reviews

2000 Dodge Dakota UPPER BALL JOINT DIAGNOSIS

admin — Tue, 18 Jan 2011 11:18:05 +0000

download 1. Position a floor jack under the right side lower suspension arm. 2. Raise the wheel and allow the tire to lightly contact the floor (vehicle weight relieved from the tire). 3. Mount a dial indicator (Special Tool C3339 or equivalent) solidly on the upper suspension arm (Fig. 1 ). Fig. 1: Right Side View [...]

2000 Dodge Dakota UPPER BALL JOINT DIAGNOSIS is a post from: Auto Repair Manual Free Download and Reviews

2001 Dodge Durango VEHICLE THEFT SECURITY SYSTEM DESCRIPTION

admin — Tue, 18 Jan 2011 11:16:16 +0000

download Anti-Theft Systems – Dakota & Durango DESCRIPTION VEHICLE THEFT SECURITY SYSTEM Vehicle Theft Security System (VTSS) provides perimeter protection against unauthorized use or tampering by monitoring vehicle’s doors, ignition system and liftgate (Durango). VTSS flashes headlights and sounds horn if any door, hood or liftgate (Durango) is opened without using valid key [...]

2001 Dodge Durango VEHICLE THEFT SECURITY SYSTEM DESCRIPTION is a post from: Auto Repair Manual Free Download and Reviews