Auto Repair Manual Free Download and Reviews » repair and maintenance tips

How To Use Boost Gauge To Control Surbo

admin — Fri, 31 Dec 2010 00:07:50 +0000

download Here is one idea that will let you utilize the Surbo system to the maximum. Attaching a boost gauge, you will be able to get the most power per throttle travel (->press less, get more power). It’s not for measuring a boost output, but as a means of consistently commanding the Surbo, especially under low-torque [...]

How To Use Boost Gauge To Control Surbo is a post from: Auto Repair Manual Free Download and Reviews

ANTI-LOCK BRAKE SYSTEM System Components System Description

admin — Sat, 25 Sep 2010 06:02:10 +0000

download SENSOR The sensor unit consists of a gear-shaped sensor rotor and a sensor element. The element contains a bar magnet around which a coil is wound. The sensor is installed on the back side of the brake rotor. Sine-wave current is generated by the sen- sor as the wheel rotates. The frequency and voltage increase(s) [...]

ANTI-LOCK BRAKE SYSTEM System Components System Description is a post from: Auto Repair Manual Free Download and Reviews

Differential Drive Pinion Gear Bearing Replacement (8.6 Inch, 9.5 Inch Axle) Removal Procedure Installation Procedure

admin — Sat, 25 Sep 2010 05:58:25 +0000

download Removal Procedure 1. 2. 3. 4. 5. 6. Raise the vehicle. Remove the tire and wheel assemblies. Remove the brake drums Remove the axle shafts. Remove the differential. Remove the drive pinion from the axle. 7. Press the bearing off of the pinion using theJ 22912-B . 8. Remove the shim. 9. [...]

Differential Drive Pinion Gear Bearing Replacement (8.6 Inch, 9.5 Inch Axle) Removal Procedure Installation Procedure is a post from: Auto Repair Manual Free Download and Reviews

POSITIVE CRANKCASE VENTILATION Description

admin — Fri, 24 Sep 2010 06:03:25 +0000

download This system returns blow-by gas to the intake manifold. The positive crankcase ventilation (PCV) valve is provided to conduct crankcase blow-by gas to the intake manifold. During partial throttle operation of the engine, the intake manifold sucks the blow-by gas through the PCV valve. Normally, the capacity of the valve is sufficient to handle [...]

POSITIVE CRANKCASE VENTILATION Description is a post from: Auto Repair Manual Free Download and Reviews

REFRIGERATION SYSTEM Checking of Refrigerant Volume

admin — Sat, 26 Jun 2010 03:35:03 +0000

download 1. RUN ENGINE AT APPROX. 1,500 RPM 2. OPERATE AIR CONDITIONER AT MAXIMUM COOLING FOR A FEW MINUTES 3. CHECK AMOUNT OF REFRIGERANT Observe the sight glass on the receiver. Insufficient* (1) Check for gas leakage with gas leak Bubbles present in sight glass tester and repair if necessary (2) Add refrigerant until bubbles disappear [...]

REFRIGERATION SYSTEM Checking of Refrigerant Volume is a post from: Auto Repair Manual Free Download and Reviews

CHECK AND ADJUSTMENT OF BRAKE PEDAL

admin — Fri, 25 Jun 2010 04:49:00 +0000

download CHECK THAT PEDAL HEIGHT IS CORRECT Pedal height from floor panel: 42.8-152.8 mm (5.62-6.02 in.) If the pedal height is incorrect, adjust it. IF NECESSARY, ADJUST PEDAL HEIGHT (a) Remove the under cover. (b) Remove the lower pad and air duct. (c) Remove the power steering ECU and disconnect the connector from the stop light [...]

CHECK AND ADJUSTMENT OF BRAKE PEDAL is a post from: Auto Repair Manual Free Download and Reviews

Removing and installing injection pump

admin — Fri, 25 Jun 2010 00:57:54 +0000

download Rotate crankshaft in direction of rotation to 14o + 0.5o (arrow) after ignition TDC of cylinder 1 Unscrew central securing bolt (40/3) Remove chain tensioner Unplug socket of injection pump (Y23/1) at plug connection Unbolt engine wiring harness (1) at oil filter housing Unplug connector at electronic IFI shutoff (Y1/1) Detach fuel lines (arrows) at [...]

Removing and installing injection pump is a post from: Auto Repair Manual Free Download and Reviews

Troubleshooting Anti-lock Brake System (ABS) Indicator Light

admin — Thu, 24 Jun 2010 10:24:10 +0000

download Temporary Driving Conditions: 1. The ABS indicator light comes on and the ABS con- trol unit memorizes the diagnostic trouble code (DTC) under certain conditions. NOTE: The DTCs are explained on page 19-56. • The tire(s) adhesion is lost due to excessive cor- nering speed. DTC: 5, 5-4, 5-8. • The vehicle loses traction when [...]

Troubleshooting Anti-lock Brake System (ABS) Indicator Light is a post from: Auto Repair Manual Free Download and Reviews

ON?VEHICLE INSPECTION INSPECT INJECTOR OPERATION

admin — Thu, 24 Jun 2010 03:50:05 +0000

download ON?VEHICLE INSPECTION 1. INSPECT INJECTOR OPERATION Check operation sound from each injector. (a) With the engine running or cranking, use a sound scope to check that there is normal operating noise in proportion to engine rpm. (b) If you have no sound scope, you can check the injector transmission operation with your finger. If no [...]

ON?VEHICLE INSPECTION INSPECT INJECTOR OPERATION is a post from: Auto Repair Manual Free Download and Reviews

Columbia Workshop Manual Refrigerant Compressor, Sanden Clutch Assembly Removal, Inspection, and Installation

admin — Wed, 23 Jun 2010 23:55:29 +0000

download Shaft Key 9. Cylinder Head 16. Drive Plate Felt Ring 10. Cylinder Head Bolt 17. Clutch Shims Shaft Seal Snap Ring 11. Pressure Relief Valve 18. Shaft Key Shaft Seal (with O-ring) 12. Thermal Protector Switch, TPS 19. Pulley Bearing Dust Cover Oil Plug (optional) 20. Pulley Snap Ring Block Gasket 13. TPS Clip (optional) [...]

Columbia Workshop Manual Refrigerant Compressor, Sanden Clutch Assembly Removal, Inspection, and Installation is a post from: Auto Repair Manual Free Download and Reviews