Auto Repair Manual Free Download and Reviews » Suzuki

1992–1995 Suzuki Samurai Engine Swap Wire Harness Instructions 1.6L, 16-Valve

admin — Thu, 26 May 2011 01:17:11 +0000

download Much has been written about swapping Suzuki’s G16B 1.6 liter 16-valve engine into the Samurai. It is mechanically very simple (as engine swaps go) but the wiring can be a daunting challenge for many. To date it has been necessary for the DIY builder to perform extensive research, gather all the information they can find, [...]

1992–1995 Suzuki Samurai Engine Swap Wire Harness Instructions 1.6L, 16-Valve is a post from: Auto Repair Manual Free Download and Reviews

1992 Suzuki Swift VALVE CLEARANCE ADJUSTMENT

admin — Thu, 26 May 2011 01:14:26 +0000

download NOTE: Samurai & Sidekick 1) Remove rocker cover. Rotate crankshaft until zero degree (TDC) timing mark of timing belt cover is in line with timing mark on crankshaft pulley. 2) Cylinder No. 1 should be at TDC on compression stroke. Remove distributor cap, and ensure rotor is pointed upward at distributor hold-down bolt and [...]

1992 Suzuki Swift VALVE CLEARANCE ADJUSTMENT is a post from: Auto Repair Manual Free Download and Reviews

Suzuki Sierra/Samurai CV Joint Removal

admin — Thu, 26 May 2011 01:11:11 +0000

download If your CV is leaking grease (see 1.1) or has oil dripping from it you will need to replace the axle oil seal. To do this you will need to remove the CV joint. It is best to buy a kit that contains new seals and king pin bearings. You may as well replace them [...]

Suzuki Sierra/Samurai CV Joint Removal is a post from: Auto Repair Manual Free Download and Reviews

2010 Suzuki KIZASHI COUNTERMEASURE OF INSTRUMENT PANEL CENTER LOWER BOX

admin — Wed, 16 Mar 2011 09:38:26 +0000

download MODEL(S): YEAR: CONDITION: CAUSE: CORRECTION: KIZASHI (A6B424) 2010 (BUILT BETWEEN OCTOBER 13, 2009 TO JUNE 17, 2010) The hinged door on the instrument panel center lower box may not remain closed in the event of a crash. Improper design of the latch mechanism. Please replace the instrument panel [...]

2010 Suzuki KIZASHI COUNTERMEASURE OF INSTRUMENT PANEL CENTER LOWER BOX is a post from: Auto Repair Manual Free Download and Reviews

Suzuki Swift GTi Extra Injector Controller Installation

admin — Fri, 31 Dec 2010 00:14:06 +0000

download Monitoring of the duty cycle of the OEM injectors. • Ability to drive more than one injector. • The magnetic pickup will no longer be used for speed sensing. This will allow interfacing to any type of vehicle with an ignition coil. • Addition of Peak and Hold Circuitry to save power and offer better [...]

Suzuki Swift GTi Extra Injector Controller Installation is a post from: Auto Repair Manual Free Download and Reviews

Suzuki Sidekick Engine Information and Options for Upgrading

admin — Fri, 31 Dec 2010 00:11:00 +0000

download Engine Options for the Samurai There are a number of possibilities for changing the engine in your Samurai, depending on where you live and what you want to accomplish. Suzuki Sidekick or Geo Tracker I (1989-1995) – The block from the 1.6 8-valve Sidekick or Tracker can be swapped in easily. This is [...]

Suzuki Sidekick Engine Information and Options for Upgrading is a post from: Auto Repair Manual Free Download and Reviews

1990-1993 Suzuki Swift DISASSEMBLY OF COMPRESSOR

admin — Thu, 30 Dec 2010 23:54:35 +0000

download Fig. 5: 1. Remove oil felt. Using a screw driver, pry out oil felt. See Fig. 6. 2. Remove key. Using a hammer and punch, drive key from shaft. Disassembly of Compressor See Fig. 7. 3. Remove circlip. Using snap ring pliers, remove circlip. See Fig. 8. 4. Apply compressor oil to [...]

1990-1993 Suzuki Swift DISASSEMBLY OF COMPRESSOR is a post from: Auto Repair Manual Free Download and Reviews

2004 Suzuki Forenza Concentric Slave Cylinder Removal and Installation Removal

admin — Sat, 30 Oct 2010 01:06:41 +0000

download 1. Remove the transaxle from the vehicle. 2. Remove the concentric slave cylinder retaining bolts. 3. Disconnect the concentric slave cylinder pipe from the concentric slave cylinder. 4. Remove the bushing from the concentric slave cylinder pipe in the transaxle housing. 5. Remove the concentric slave cylinder pipe. 6. Remove the O-ring and the concentric [...]

2004 Suzuki Forenza Concentric Slave Cylinder Removal and Installation Removal is a post from: Auto Repair Manual Free Download and Reviews

2005 Suzuki Verona Intake Manifold Removal

admin — Sat, 23 Oct 2010 11:18:18 +0000

download 1. Remove the fuel pump fuse. 2. Start the engine and repeat cranking until the remaining fuel in the fuel line is all consumed. 3. Disconnect the negative battery cable. 4. Drain the engine coolant. 5. Remove the engine beautification cover retaining nut and engine beautification cover. 6. Remove the air filter snorkel. 7. Remove [...]

2005 Suzuki Verona Intake Manifold Removal is a post from: Auto Repair Manual Free Download and Reviews

1995 Suzuki Sidekick AUTOMATIC TRANSMISSIONS Hydra-Matic 3L30

admin — Thu, 07 Oct 2010 00:23:33 +0000

download IDENTIFICATION Transmission is identified by identification plate attached to transmission case, located on left side, above oil pan. Vehicle Identification Number (VIN) may also be used in identifying transmission. VIN locations are at top left of instrument panel and driver’s-side door post. VIN is used to ensure correct application of component parts and assemblies. [...]

1995 Suzuki Sidekick AUTOMATIC TRANSMISSIONS Hydra-Matic 3L30 is a post from: Auto Repair Manual Free Download and Reviews