download
1995-96 STARTING & CHARGING SYSTEMS Volkswagen Starters Cabrio, Golf III, GTI, Jetta III DESCRIPTION Starter is a brush type, series-wound electric motor with an overrunning clutch. Field frame is enclosed by commutator end frame and drive bushing, and carries pole shoes and field coils. A splined armature shaft drive end carries drive assembly. TROUBLE SHOOTING NOTE: ON-VEHICLE TESTING STARTER DOES NOT CRANK ENGINE 1) Ensure battery is fully charged. Ensure electrical and ground connections are clean and tight. With ignition switch in START position, measure voltage at spade terminal of starter solenoid. Reading should be at least 8 volts. If voltage is as specified, go to step 3). If voltage is not as specified, go to next step. 2) Measure voltage at ignition switch. If reading is at least 8 volts, check wiring between ignition switch and starter solenoid. If voltage is not as specified, replace ignition switch. 3) While operating starter, measure voltage at field (starter) terminal of starter solenoid. If reading is at least 8 volts, repair or replace starter. If reading is less than 8 volts, replace starter solenoid. NOTE: See TROUBLE SHOOTING article in GENERAL INFORMATION. On vehicles with automatic transmission, also check park/neutral switch. STARTER CRANKS TOO SLOWLY TO START ENGINE Ensure battery is fully charged. Ensure electrical and ground connections are clean and tight. If necessary, clean and tighten ground strap between transmission and body. DO NOT loosen ground strap on body. If starter still turns slowly, repair or replace starter. REMOVAL & INSTALLATION Removal & Installation 1) Disconnect negative battery cable. Support engine/transmission assembly with Support Beam (VW 10-222A) and Leg
Related posts:
- 1996 Volkswagen Golf BRAKE PRESSURE REGULATOR ADJUSTMENTS
- 1993 – 2002 Volkswagen A3 Platform checking Ignition coil power output stage
- 1999-2006 Volkswagen A4 Generic Scan Tool, Engine Code(s): AEG 20 – Electronic Engine Power Control
- 1996 Volkswagen Golf ADJUSTMENTS AIR BAG SPIRAL SPRING REMOVAL & INSTALLATION
- 2001 Volkswagen Jetta GL STARTER Removal & Installation (With 4-Speed Automatic 01M Transaxle & 5-Speed Manual 02J Transaxle)
